Recycled rockets: SpaceX calls time on expendable launch vehicles

Falcon 9 launch Falcon 9: The lower part of the rocket - its first-stage - will eventually carry landing gear

Have we witnessed the beginning of a revolution in rocketry?

On Sunday, the SpaceX company launched the latest version of its Falcon 9 vehicle from California, placing a cluster of small satellites in low-Earth orbit.

The new vehicle has been given the additional performance it needs to start lofting commercial telecoms spacecraft and other payloads, and nearly all of these modifications appear to work just fine.

But it's what happened to part of the rocket after it had completed the primary mission goals - as it fell to Earth - that really has everyone talking.

Normally, the first-stage of a rocket – the segment that gets it up off the ground – is discarded at altitude, whereupon it begins a destructive dive back through the atmosphere.

Aerodynamic forces tear the tumbling object apart. This is the history of rocketry – everything is expendable.

SpaceX, though, has plans to try to recover these stages in good working order, to refurbish them and to put them back on the launch pad.

If the company can succeed, it would have a major impact on the cost of access to space. Expendable rockets would become reusable. Parts of them, certainly.

To this end, Sunday’s first-stage was commanded to reignite three of its nine engines after separation from the rocket’s upper-stage in an attempt to slow its return to Earth.

Then, as the stage got closer to the Pacific Ocean, it fired up a fourth engine to limit the descent speed still further.

SpaceX CEO and chief designer Elon Musk promises to post video on the web later this week showing what happened.

Although the stage lost some stability as it approached the water, the entrepreneur expressed great satisfaction with the way the experiment went.

Start Quote

If things go super-well then we will be able to refly a Falcon 9 stage before the end of next year”

End Quote Elon Musk SpaceX CEO

“In this case, the boost stage did not have landing gear, which helps essentially to stabilise the stage like fins on an aircraft.

“The stage actually ended up spinning to a degree that was greater than we could control with the gas thrusters, and it centrifuged the propellant. It caused the boost stage to run out of propellant before hitting the water. So it hit the water relatively hard.

“We’ve recovered portions of the stage, but the most important thing is we believe we now have all the pieces of the puzzle.”

Those "pieces" comprise the lessons learned from Sunday and the results garnered from SpaceX’s Grasshopper programme, in which a Falcon first-stage has executed precision take-offs and landings from a pad in Texas. A number of videos illustrate these hops. Note the landing legs.

Grasshopper test The Grasshopper programme has run a series of precision take-offs and landings

Retractable versions will now be incorporated on to the Falcon 9 that launches the company’s next Nasa cargo mission to the space station from Florida at the beginning of 2014.

And again, once the first-stage has completed its primary tasks on that flight, it will be commanded to reignite its engines and to make a controlled return to Earth.

Start Quote

The first-stage represents almost three-quarters of the cost of a Falcon 9”

End Quote

But it won’t drop into the ocean. This time, the boost stage will try to touch down on a piece of ground at Cape Canaveral not far from the launch pad.

SpaceX is currently working through the technicalities with range officials at the Cape, and with the Federal Aviation Authority. An FAA licence will be needed before such a landing is permitted.

Obviously, with a load of kerosene fuel onboard, all matters of safety will have to be satisfied first.

“For any landing area, the landing ellipse - the error that the stage could encounter - would be an unpopulated region,” Musk tells me. "We would aim to have a landing site that’s unpopulated with a radius of probably a couple of miles."

SpaceX’s Falcon 9 rocket is currently being offered at about $54m a launch. That is very competitive by today’s standards, but it would be substantially cheaper still if elements of the rocket could be recycled. The company says the first-stage represents almost three-quarters of the cost of a Falcon 9.

Clearly, in carrying extra fuel and landing gear, you take a hit on the rocket’s performance – the maximum payload you can carry to orbit is cut by about 30% if you try to return the first-stage to the launch site, says Musk. But the imperative is clear.

“In terms of when we actually refly the stages, it’s going to depend on what condition the stage is in, and obviously getting customers comfortable with that,” Musk explains.

"If things go super-well then we will be able to refly a Falcon 9 stage before the end of next year. That’s our aspiration."

Jonathan Amos Article written by Jonathan Amos Jonathan Amos Science correspondent

Lisa Pathfinder: 'Exquisite' gravity probe leaves UK

UK industry completes construction of the modules that make up the Lisa Pathfinder satellite - a remarkable probe that will test the key technologies needed to detect gravitational waves in space.

Read full article


This entry is now closed for comments

Jump to comments pagination
  • rate this

    Comment number 13.

    5.Balloon Rake

    A commercial company putting commercial payloads into orbit for companies to provide Earth centric commercial services such as telecommunications, GPS, weather, agricultural data, surveying, imaging and maybe even some blue skies research projects that add to the sum total of human knowledge. Now back under your rock, there's a good fellow.

  • rate this

    Comment number 8.

    @Balloon Rake "A complete waste of money from scientists who have too much time on their hands, space exploration is pointless, it's the pipe dream of sc-fi fans."

    Maybe its your tunnel vision, lack of imagination, or failure to look outside the box that's the issue?

  • rate this

    Comment number 7.

    Balloon Rake: This is a commercial company that is doing this. Even ignoring Elon's stated goals of getting humans to Mars, The satellites he is launching will also be for telecommunications and earth observation. The work Spacex is doing will massively bring down launch costs, allowing more of these incredibly useful, even essential satellites to be launched.

  • rate this

    Comment number 30.

    A pipe dream, you say? So was landing on the moon not long ago. Done that! Nothing is impossible if you can conceive it - you just have to figure out how to make it happen.

    Space offers us huge potential, from resources to living space - not to mention an insurance policy against mass extinction events.

    If we don't spread to other worlds the eventual extinction of Earth life is guaranteed.

  • rate this

    Comment number 4.

    It's great to see some changes happening to expendable rocket culture. Although it's a shame it taken someone so long to implment it, Thunderbird 3 was doing this back in the 1960's!!


Comments 5 of 104


Features & Analysis

  • Cartoon of women chatting on the metroChat wagon

    The interesting things you hear in a women-only carriage

  • Replica of a cargo boxSpecial delivery

    The man who posted himself to the other side of the world

  • Music scoreFinal score Watch

    Goodbye to NYC's last classical sheet music shop

  • Former Secretary of State Hillary Rodham Clinton checks her Blackberry from a desk inside a C-17 military plane upon her departure from Malta, in the Mediterranean Sea, bound for Tripoli, Libya'Emailgate'

    Hillary gets a taste of scrutiny that lies ahead

BBC Future

What's life like when you get drunk on rice and potato? (Getty Images)

The man who gets drunk on chips

He brews beer inside his belly


  • A robotClick Watch

    The latest in robotics including software that can design electronics to solve problems

Copyright © 2015 BBC. The BBC is not responsible for the content of external sites. Read more.

This page is best viewed in an up-to-date web browser with style sheets (CSS) enabled. While you will be able to view the content of this page in your current browser, you will not be able to get the full visual experience. Please consider upgrading your browser software or enabling style sheets (CSS) if you are able to do so.